作者：宗明明1, 李涛1, 杨建明1, 邹梦丹1, 甘涛2
作者单位：1. 三江学院土木工程学院，江苏 南京 210012;
2. 南昌市政建设集团有限公司，江西 南昌 330013
关键词：磷酸钾镁水泥;硫酸盐;浸泡;干湿循环;水玻璃
摘要：
为研究硫酸盐环境下水玻璃对磷酸钾镁水泥（mkpc）浆体力学的影响，该文测试mkpc浆体在5%硫酸钠溶液中干湿循环30 ~180次后的强度和吸水率，并与mkpc浆体浸泡在5%硫酸钠溶液中的强度及吸水率进行对比。结果表明：mkpc浆体经过180次硫酸盐干湿循环和90 d长期浸泡试验后，其强度相比初始值分别提高16.79%、38.13%，且吸水率远低于初始值，体现mkpc浆体优异的抗硫酸盐腐蚀能力；加入适量的水玻璃后， mkpc浆体的强度得到了提高，同时耐硫酸盐腐蚀能力也得到改善。
effect of sodium silicate in sulfate environment on the mechanics of potassium magnesium phosphate cement slurry
zong mingming1, li tao1, yang jianming1, zou mengdan1, gan tao2
1. college of civil engineering, sanjiang university, nanjing 210012, china;
2. nanchang municipal construction group co., ltd., nanchang 330013, china
abstract: in order to study the effect of sodium silicate on the mechanical properties of magnesium phosphate cement (mkpc) slurry in sulfate environment. in this paper, the strength and water absorption of mkpc slurry after drying and wetting for 30 to 180 times in 5% sodium sulfate solution were tested. the strength and water absorption of mkpc slurry soaked in 5% sodium sulfate solution were compared. the results showed that the strength of mkpc slurry increased by 16.79% and 38.13% compared with the initial value after 180 cycles of sulfate drying and wetting and 90 days of long-term immersion test, respectively, and the water absorption rate was much lower than the initial value, which showed that mkpc slurry had excellent sulfate corrosion resistance. with the addition of sodium silicate, the strength of mkpc slurry was improved and the sulfate corrosion resistance was also improved.
keywords: potassium magnesium phosphate cement;sulfate;immersion;drying and wetting cycle;sodium silicate
2023, 49(3):152-158 收稿日期: 2021-08-16;收到修改稿日期: 2021-11-05
基金项目: 国家自然科学基金面上项目（51578475）
作者简介: 宗明明(1984-),男,江苏南京市人,实验师,本科,主要从事磷酸镁水泥的研究
参考文献
[1] 沈曦. 国外海洋工程高技术发展状态[j]. 中国海洋平台, 1996, 11(1): 5-9
[2] 王复生, 孙瑞莲, 秦小鹃. 察尔汗盐湖条件下水泥混凝土耐久性调查研究[j]. 硅酸盐通报, 2002(4): 16-22
[3] chen d, mahadevan s. chloride-induced reinforcement corrosion and concrete cracking simulation[j]. cement and concrete composites, 2008, 30(3): 227-238
[4] gao jm, yu zx, song lg. durability of concrete exposed to sulfate attack under flexural loading and drying-wetting cycles[j]. construction and building materials, 2013, 39: 33-38
[5] 乔宏霞, 周茗如, 何忠茂, 等. 硫酸盐环境中混凝土的性能研究[j]. 应用基础与工程科学学报, 2009, 17: 77-84
[6] 马楠, 王琳, 李迎乐, 等. 干湿交替机制下pva纤维增强混凝土抗硫酸盐侵蚀性能试验研究[j]. 中国测试, 2021, 47(7): 142-147
[7] 杨春景, 孙红霞, 朱鹏宇, 等. 硫酸盐侵蚀玄武岩纤维轻骨料混凝土力学性能研究[j]. 中国测试, 2021, 47(6): 68-74
[8] cheewaket t, jaturapitakkul c, chalee w. concrete durability presented by acceptable chloride level and chloride diffusion coefficient in concrete: 10-year results in marine site[j]. materials and structures, 2013, 47(9): 1501-1511
[9] 解咏平, 贾磊, 李慎奎, 等. 高性能混凝土抗硫酸盐侵蚀的试验研究[j]. 建筑结构, 2017, 47(6): 70-73
[10] khanzadeh m m, shekarchi m, hoseini m. time-dependent performance of concrete surface coatings in tidal zone of marine environment[j]. construction and building materials, 2012, 30: 198-205
[11] 黄微波, 马红亮, 李志高. 聚氨酯和聚脲涂层对混凝土氯离子渗透性的影响[j]. 混凝土, 2011(6): 94-96
[12] yang q b. durability and applications of magnesium phosphate material for rapid repair of pavements[j]. advanced materials research, 2013, 857: 81-89
[13] 李涛. 磷酸钾镁水泥基复合材料耐久性的试验研究[d]. 南京: 南京工业大学, 2015.
[14] 张洁. 磷酸钾镁合成和溶解因素的影响规律及其作用机理[d]. 石家庄: 石家庄铁道大学, 2018.
[15] 李金玉, 曹建国, 徐文雨, 等. 混凝土冻融破坏机理的研究[j]. 水利学报, 1999, 30(1): 41-49
