作者：康靖, 赵庆海
作者单位：西安理工大学印刷包装工程学院, 陕西西安 710048
关键词：红外二级管; 恒功率; 纠偏探头; 光生电流; 运算放大器
摘要：
通过直流电路驱动红外二级管发出的红外光恒功率发射,红外光经过聚光透镜,形成直径为20mm的光柱。带材正常运动时处于光柱的中心位置,光电二极管接收到的光功率为一定值;当带材偏移时,引起接收管的光功率变化,导致光生电流变化,从而确定偏移量与光生电流的关系。在信号的放大与处理环节采用两级运算放大器相结合的电路,充分减少信号衰减与噪声影响,并产生较大的电压增益,试验表明该电路设计可行并达到一定的精度。
design and validate excursion sensor based on infrared diode
kang jing, zhao qing-hai
school of printing and packing engineering, xi'an university of technology, xi'an 710048, china
abstract: the infrared diode was droved by dc circuit to send light with constant power. the rays passed through a condensing lens and formed a light pole with the diameter of 20 mm. when the web worked normally, it passed through the central axle of the light pole so that the optical power received by photosensitive diode was normal constant. on the contrary, if the web went with excursion, different luminous flux would be gotten by the photosensitive diode. furthermore, the photocurrent which had a direct proportion relationship with the luminous flux would be changed too. based on the above, the relationship between the excursion and the photocurrent could be determined. using two operational amplifiers to amplify and deal with the current signals, it could lessen the signal attenuation and yawp infections and produce biggish voltage plus. the experimental results shows that this designed circuit is available and with certain accuracy.
keywords: infrared diode; constant power; excursion sensor; photocurrent; operational amplifier
2008, 34(3): 127- 收稿日期: 2007-9-12;收到修改稿日期: 2007-11-27
基金项目:
作者简介: 康靖(1983-),女,湖北襄樊人,硕士研究生,专业方向为测控技术应用及研究。
参考文献
[1] 高稚允, 高岳. 光电检测技术[m].北京:国防工业出版社, 1995.
[2] 康华光.电子技术基础(模拟部分)[m].4版.北京:高等教育出版社, 1998.
[3] 张烽生, 龚全宝.光电子器件应用基础[m].北京:机械工业出版社, 1993.
[4] 秦积荣.光电检测原理及应用(下册)[m].北京:国防工业出版社, 1989.
[5] 朱新连, 张海燕, 赵庆海.卷筒纸纸袋跑偏检测与纠正系统[j].传感器技术, 2005(7):57-59.
[6] 陈永甫.红外探测与控制电路[m].北京:人民邮电出版社, 2004.
[7] 杨家德.光电技术实用电路精选[m].成都:成都科技大学出版社, 1996.
[8] 导向科技.protel dxp电子电路设计培训教程[m].北京:人民邮电出版社, 2003.
[9] 叶嘉雄, 等.光电系统与信号处理[m].北京:科学出版社, 1997.
[10] 陈永甫.红外辐射红外器件与典型应用[m].北京:电子工业出版社, 2006.
[11] 江月松, 阎平, 刘振玉.光电技术与实验[m].北京:北京理工大学出版社, 2000.
[12] 周惠潮.常用电子元件及典型应用[m].北京:电子工业出版社, 2005.
